Product ID:VULKEM 200L, 605412000
MSDS Date:06/06/1988
FSC:8010
NIIN:00N039072
MSDS Number: BRJSW

RPM MAMECO INTERNATIONAL

4475 EAST 175TH ST
CLEVELAND, OH 44128
US

Emergency Phone: 216-752-4400

Info Phone: 216-752-4400

Cage: GO142

RPM MAMECO INTERNATIONAL

CLEVELAND, OH 44128-3411 US

Telephone: 216-752-4400

Cage: GO142

COAL TAR

CAS: 65996-89-6

RTECS: GF8600100

Fraction By Weight: 50%

OSHA PEL N/K

ACGIH TLV: N/K

CLARIFIED SLURRY OIL; (AROMATIC HYDROCARBON)

CAS: 64741-62-4

RTECS: GF0960000

Fraction By Weight: 20%

OSHA PEL N/K

ACGIH TLV: N/K

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: < 5%

OSHA PEL 100 PPM;150 STEL

ACGIH TLV: 100 PPM;150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

AROMATIC ISOCYANATES CONSISTING OF INGREDIENTS 5,6, & 7.

RTECS: 9999999ZZ

Fraction By Weight: <0.5%

OSHA PEL N/K

ACGIH TLV: N/K

POLYMETHYLENE POLYPHENYL ISOCYANATE

CAS: 9016-87-9

RTECS: TR0350000

OSHA PEL N/K

ACGIH TLV: N/K

ISOCYANIC ACID, METHYLENEDI-P-PHENYLENE ESTER (SARA III)

CAS: 101-68-8

RTECS: NQ9350000

OSHA PEL N/K

ACGIH TLV: N/K

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

ISOCYANIC ACID, METHYL-M-PHENYLENE ESTER (SARA III)

CAS: 26471-62-5

RTECS: NQ9490000

OSHA PEL N/K

ACGIH TLV: N/K

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:VAPORS ARE IRRITATING WHEN HOT. LOW
ORDER OF ACUTE ORAL TOXICITY. MAY BE IRRITATING TO RESPIRATORY
TRACT AND EYES. CERTAIN AROMATIC HYDROCARBONS HAVE BEEN SHOWN TO
CAUSE CANCER IN EXPERIMENTAL ANIMALS AND MAN FOLLOWING PROLONGED
OR REPEATED CONTACT.
Explanation of Carcinogenicity:TOLUENE DIISOCYANATE (26471-62-5): GROUP
2B, IARC MONOGRAPHS, VOL SUPPLEMENT 7, PAGE 56, 1987.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:AVOID SKIN CONTACT. SKIN: THOROUGHLY WASH EXPOSED AREA WITH
SOAP AND WATER. EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MIN. GET MEDICAL ATTN. INGEST: DO NOT INDUCE VOMITING. GET
MEDICAL A TTN. INHAL: REMOVE TO FRESH AIR. IF NECESSARY, ADMINISTER
OXYGEN AND/OR ARTF RESP. GET MEDICAL ATTENTION.

Flash Point Method:SCC
Flash Point:190F,88C
Extinguishing Media:WATERSPRAY, WATERFOG, DRY CHEMICAL, FOAM, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TOXIC GASES MAY OCCUR AS DECOMPOSITION
PRODUCTS. REACTION WITH WATER PRODUCES CARBON DIOXIDE WHICH COULD
CAUSE PRESSURE TO BUILDUP IN A CLOSED CONTAINER.

Spill Release Procedures:ABSORB INTO VERMICULITE OR OTHER ABSORBENT
MATERIAL AND DISPOSE. CLEAN AFFECTED AREA WITH SOLVENT FOLLOWED BY
SOAP AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:PROTECT CONTAINERS FROM PHYSICAL
DAMAGE. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:FOR SAFETY, STORE AT TEMPS NOT EXCEEDING 180F AWAY
FROM SPARKS OR FLAME. FOR MAXIMUM STORAGE LIFE STORE AT LESS THAN
90F. DO NOT BREATHE VAPORS. AVOID SKIN AND EYE CONTACT. DO NOT TAKE
INTERNALLY.

Respiratory Protection:USE WITH ADEQUATE VENTILATION. NIOSH/MSHA
APPROVED RESPIRATORS WITH ORGANIC VAPOR CARTRIDGES OR SCBA MAY BE
USED IN CONFINED AREAS.
Ventilation:LOCAL EXHAUST OR GENERAL MECHANICAL SUFFICIENT TO PREVENT
ACCUMULATION OF FUMES.
Protective Gloves:BUNA-N, PLASTIC, OR RUBBER.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

Boiling Pt:B.P. Text:280F,138C
Vapor Density:HVR/AIR
Spec Gravity:1.08
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:15

Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, STRONG OXIDIZING AGENTS, STRONG BASES, STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NITROGEN OXIDES, HYDROGEN CYANIDE,
CARBON MONOXIDE, CARBON DIOXIDE.

Waste Disposal Methods:INCINERATE OR LANDFILL IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL ENVIRONMENTAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.